空压机技术文章

空压机长期停放注意事项

2018-11-23 10:17:34      点击:
空压机的停用在各个单位都常有发生。那么在初次开机前空压机停放时间超过三个月或空压机停用时间超过三个月,再次开机前需要采取有效措施,bi须先请专业空压机人员对机器进行保养检测,制定安全措施,避免开机后发生不良状况。

The shutdown of air compressors often occurs in various units. Then, before the first start-up, the air compressor parking time is more than three months or the air compressor parking time is more than three months. Before the second start-up, effective measures need to be taken. The Bi must first ask professional air compressor personnel to carry out maintenance and inspection of the machine, and formulate safety measures to avoid adverse conditions after the start-up.



1、先检查电路状态,是否正常供电,电压是否稳定;测量电动机绝缘电阻,数值大于1MΩ。

1. Check the state of the circuit first, whether the power supply is normal, whether the voltage is stable; Measure the insulation resistance of the motor, the value is greater than 1M.



2、检查空压机配件上是否含有积水,灰尘,及时清理。

2. Check whether there is water and dust on the spare parts of air compressor, and clean them up in time.



3、对进气口,出气口全面检测,防止发生堵塞现象

3. Overall inspection of intake and outlet to prevent blockage



4、在上述都已经完成的情况可以接通电源,查看电脑控制器是否正常运行

4. If all the above have been completed, the power supply can be connected to check whether the computer controller is working properly.



5、更换三滤和润滑油。因为在长期不用的情况下,三滤,油可能发生老化现象,从而造成空压机开机运行时间不长即结胶积碳或堵塞,油路不畅使空压机主机或其他零部件损坏。

5. Replace three filters and lubricants. Because in the case of long-term non-use, three filters may cause oil aging phenomenon, which causes the air compressor start-up time is not long, that is, cementing carbon deposit or blockage, oil circuit is not smooth, so that air compressor main engine or other parts are damaged.



6、专业人员试机,电路改造后人工控制加载卸载,先空载运行10分钟以上,检测各项指标和震动、噪音等正常,再进行加载,查看各部件运行正常即可。

6. Professional personnel test machine, after circuit modification, manual control loading and unloading, first no-load operation for more than 10 minutes, detection of various indicators and vibration, noise and other normal, then load, check the normal operation of the components.
QQ客服
微信二维码
皇冠彩票官网 欢乐生肖怎么玩 云鼎彩票 欢乐生肖开奖结果 568彩票官网 鼎盛彩票官网 鑫彩网彩票 秒速时时彩 重庆欢乐生肖开奖记录 云顶彩票